TO THE COMPARATIVE EVALUATION OF FUEL ECONOMY OF THE BTR-70 CAR WITH DIFFERENT TRANSMISSION

ABSTRACT

Sakhno V.P., Dykykh O.V. To the comparative assessment of fuel economy of the BTR-70 car with different gearboxes. Visnyk of National Transport University. Series «Technical sciences». Scientific and Technical Collection. – Kyiv: National Transport University, 2021. – Issue 3 (50).

The article considers the issue of choosing a gearbox for the modernization of the BTR-70 by replacing two gasoline engines with two diesels.

The object of research is the fuel economy of the BTR-70 car with different gearboxes when replacing two gasoline engines with two diesels.

The purpose of the work – to determine the type and gear ratio of the transmission, which provides the best fuel efficiency of the car.

Research method - mathematical modeling.

When replacing a gasoline engine with a diesel of a different power and a different speed range, it is necessary to determine the gear ratio so as to provide the car with the required level of speed properties in the specified operating conditions with minimal fuel consumption. Due to the fact that the modernization of the BTR-70 involves the replacement of the engine and transmission, the further search for the gearbox was carried out on the basis of analysis of existing structures by the maximum torque of the engine. A five-speed and eight-speed MAZ gearbox and a six-speed Mercedes-Benz G 85-6 / 6.7 gearbox were used for analysis. Taking into account the fact that at a given coefficient of drag  = 0.03 the car can move only in direct gear, then for all gearboxes the fuel characteristics of steady motion will be the same as the control fuel consumption, which was 30 l / 100 km. In terms of fuel consumption during the acceleration of the car and the average kilometer fuel consumption when driving on paved roads, preference should be given to a car with a Mercedes-Benz G 85-6 / 6,7 transmission and only when driving in difficult road conditions, preference should be given to the car with 8-speed MAZ-5335 transmission.

KEY WORDS: CAR, ENGINE, FUEL ECONOMY, TRANSMISSION, GEAR RATING, SPEED, COMPARATIVE EVALUATION

REFERENCES

  1. Cars. Traction-speed properties and fuel efficiency: textbook. manual / V.P. Sakhno, G.B. Bezborodova, M.M. Mayak, S.M. Sharay. – К .: КВІЦ, 2004. - 174 р.
  2. Sakhno V.P. To the choice of engine type during modernization of BTR-70 / V.P.Sakhno, D.M.Yashchenko, O.V.Dykykh, V.V.Stelmashchuk, V.P.Onishchuk // Modern technologies in mechanical engineering and transport. Scientific journal. - Lutsk NTU, 2020. - №2 (15). – P.134-146.
  3. Sakhno V.P. Before choosing the type of engine during the modernization of the BTR-70 / V.P. Sakhno, O.V.Dykykh // Collection of scientific works of the Central Research Institute of Armaments and Military Equipment of the Armed Forces of Ukraine. – 2021. – Р. 376 – 385.
  4. Sakhno V.P. etc. Performance properties of vehicles. At 3 p.m. Part 1. Dynamics and fuel efficiency of motor vehicles: [textbook] / V.P. Sakhno, A.P. Kostenko, M.I. Zagorodnov, etc. - Donetsk: Publishing House "Knowledge" (Donetsk branch), 2014. – 444 p.
  5. Litvinov A.S., Farobin J.I. Car: Theory of operational properties: A textbook for universities in the specialty "Cars and Automotive". – M .: Mashinostroenie, 1989. – 240 p.
  6. Ivanushko O., Sakhno V. Substantiation and selection of criteria for modeling rational modes of maintenance and repair. Systemyi Srodki Transportu Samochodowego. Wybrane Zagadnienia: monografia / pod redakcja naukowa Kazimierza Lejdy. Seria Transport № 10. Rzeszów: Politehnika Rzeszowska, 2017. P. 35–44.
  7. Uniform provisions concerning measures to be taken to limit emissions of gaseous and particulate pollutants from compression-ignition and positive-ignition engines for use in vehicles: UN Regulation № 49: Revision 6 [Effective 2013-01 -27]. Geneva: UN, 2013. 518 p.]
  8. Zharov K.S. Choice and substantiation of the type of car-tractor of a large-capacity road train: dis ... сand. tech. science: 05.22.02. Kyiv, 2014. 166 p.
  9. Zharov K.S. To the choice of the type of car-tractor of a three-link road train according to the indicators of fuel economy / K.S. Zharov // Motorway of Ukraine. – 2008. – № 4. – P. 17–21.
  10. Zharov K.S. Research of average speed and productivity of road trains / K.S.Zharov // Bulletin of NTU: In 2 parts: Part 1. - К .: NTU, 2008. - № 17. - P. 126-133.
  11. Sakhno V.P. Influence of constructive parameters of a road train on its productivity and efficiency / V.P. Sakhno, K.S. Zharov // Bulletin of the Donetsk Academy of Motor Transport. – 2010. – № 2. - P. 68–78.

AUTHORS

Sakhno Volodymyr P., Doctor of Technical Sciences, professor, National Transport University, head of the automobiles department, e-mail: sakhno@ntu.edu.ua, tel. +380442804252, Ukraine, 01010, Kyiv, Mykhailа Omelianovycha-Pavlenka Str. 1, of. 301, orcid.org/0000-0002-5144-7131.

Dykich Oleksandr V., MSc in transport, postgradiate student of the automobiles department, National Transport University, e-mail: aleksandrdik@ukr.net, tel. +380442804252, Ukraine, 01010, Kyiv, Mykhailа Omelianovycha-Pavlenka Str. 1, of. 301, orcid.org/0000-0002-3511-3350.

REVIEWERS

Bilichenko V.V., Doctor of Technical Sciences, Professor, Vinnytsia National Technical University, professor, head of cars and transport management, Vinnytsa, Ukraine.

Posviatenko E.K., Doctor of Technical Sciences, professor, National Transport University, professor of the production, repair and materials science department, Kyiv, Ukraine.

Article language: Ukrainian

Open Access: http://publications.ntu.edu.ua/visnyk/50/198-209.pdf

Print date: 29.09.2021

Online publication date: 30.10.2021

 

Search